Replace the air cleaner element if it is damaged. Carbon Monoxide Hazards Exhaust contains poisonous carbon monoxide, a colorless, odorless gas. Allow the gasoline to drain completely, and then install the sediment cup see page 53. Gasoline oxidizes and deteriorates over time, causing hard starting. Use 4-stroke automotive detergent oil. Unplug all tools and appliances from the generator.
The problem is that once you have gotten your nifty new product, the eb6500 honda generator owners manual gets a brief glance, maybe a once over, but it often tends to get discarded or lost with the original packaging. Know what the controls do and how to operate them. Wash the air cleaner element in a solution of household detergent and warm water and rinse thoroughly, or wash in nonflammable or high flashpoint solvent. Safety Messages Your safety and the safety of others is very important. Drain the fuel sediment cup page 53.
Set the hooks of the air cleaner cover to the setting pins securely, and then push the air cleaner cover to lock the clips. Receptacle 4, the 240-volt receptacle, has two powered terminals, 4A and 4B. The jet is in the very bottom of the center post. This manual contains all the information on how to do that; please read it carefully. You can also use fuel stabilizer to help prevent the problem in the future. Contact your authorized Honda generator dealer for stabilizer recommendations. Do not try to lift the generator by any other part.
A loose spark plug can overheat and damage the engine. Install the battery guard on the frame. If the generator is stored outdoors, unprotected from the weather, check all of the electrical components on the control panel before each use. Keep all cigarettes, sparks, and flames away from all fuel-related parts. Do not run the engine unless the instruction tells you to do so. A very rich mixture will also foul the spark plug and cause hard starting.
In some areas, generators are required to be registered with local utility companies. Old gasoline will cause hard starting, and it leaves gum deposits that clog the fuel system. Repair or replace the faulty power tool, appliance, or cord before further use. Most injuries or property damage can be prevented if you follow all instructions in this manual and on the generator. Stop and restart the engine.
Spark plug does not get wet. Fire and Burn Hazards The exhaust system gets hot enough to ignite some materials. Even with carburetor modification, engine horsepower will decrease about 3. I had installed a trickle charge cord on the battery and thought I'd just leave the battery cover off. I really think you have a fuel supply issue. Read the instructions before you begin, and make sure you have the tools and skills required. If the generator is used at a construction site, there may be additional regulations that must be observed.
You need to go to the Honda website and download a copy of the owner's manual for your specific generator and follow the step-by-step instructions for operating and troubleshooting your generator. If you change your own oil, please dispose of it properly. Please check with your servicing dealer for local storage recommendations. A low oil level will cause the Oil Alert system to shut down the engine or prevent it from starting. Other uses can result in injury to the operator or damage to the generator and other property.
If the engine stops and will not restart, check the engine oil level see page 44 before troubleshooting in other areas. Always perform a pre-operation inspection before each operation, and correct any problem. . Reinstall the air cleaner element in the air cleaner case. Failure to properly follow instructions and precautions can cause you to be seriously hurt or killed. The connection must isolate the generator power from utility power, and must comply with all applicable laws and electrical codes. Answered on Feb 26, 2019 I would suspect that the inverter is fine and would look towards carburetion.
Failure to follow this maintenance schedule could result in non-warrantable failures. Keep gasoline away from appliance pilot lights, barbecues, electric appliances, power tools, etc. Cleaning Wipe the generator with a moist cloth. Free the hooks from the setting pins on the air cleaner case and remove the air cleaner cover to the right side of the frame pipe, taking care not to damage the air cleaner cover. Control of hydrocarbons and oxides of nitrogen is very important because, under certain conditions, they react to form photochemical smog when subjected to sunlight.